Clymer Kawasaki Jet Ski (1992-1994)

Kawasaki Jet Ski, 1992-1994
Part #: W802

488 pages

CHAPTER ONE / GENERAL INFORMATION

CHAPTER TWO / TROUBLESHOOTING

CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Operational check list / Lubrication / Recommended fuel mixture / Fuel mixing / Starter gear oil / Control cable lubrication / Periodic maintenance / Fuel vent check valve inspection / Oil tank vent valve / fuel filter / Flame arrester / Impeller / Rubber coupler / On-shore cooling / Steering cable adjustment / Trim cable adjustment / Throttle cable adjustment / Choke cable adjustment / Engine tune-up / Retorque cylinder head / Compression test / Spark plug / Ignition timing / Carburetor adjustment / Fuel mixture screw initial setting / Fuel mixture adjustment / idle speed / Carburetor synchronization / Storage / Specifications

CHAPTER FOUR / ENGINE (440 AND 550 CC)
Engine lubrication / Service precautions / Serial numbers / Servicing engine in hull / Removal installation / Engine top end / Cylinder / Piston, pin and rings / Crankcase and crankshaft / Specifications
CHAPTER FIVE / ENGINE (650 AND 750 CC)
Engine lubrication / Service precautions / Serial numbers / Servicing the engine in the hull / Engine / Engine top end / Cylinder / Piston, pin and rings / Reed valve assembly / Crankcase and crankshaft / Water drain valve / Starter reduction gear / Specifications

CHAPTER SIX / DRIVE TRAIN
Drive shaft / Jet pump / Reverse system / Specifications

CHAPTER SEVEN / FUEL AND EXHAUST SYSTEMS
Flame arrestor / Mikuni carburetor / Keihin carburetor / Fuel pump / Fuel tank / Main fuel valve / Exhaust system / Exhaust system cleaning and inspection / Specifications

CHAPTER EIGHT / ELECTRICAL SYSTEMS
Battery / Charging system / Electric starting system / Capacitor discharge ignition CDI / RPM limiter / Electric box / Bilge pump test / Bilge blower / Temperature sensor switch / Stop and start switches / Specifications

CHAPTER NINE / OIL INJECTION SYSTEM
Oil pump service / Oil tank / Oil level sensor / Oil tank check valve / Oil pump / Specifications

CHAPTER TEN / BILGE SYSTEM
Vacuum-type bilge system / Electric bilge system / Specifications

CHAPTER ELEVEN / STEERING AND HULL REPAIR
Steering assembly / Trim adjuster / Hull repair / Deck frame / Specifications

INDEX

WIRING DIAGRAMS

Models covered:
1992 1993 1994 KAWASAKI JB650 Jet Mate
1992 1993 1994 KAWASAKI JF650TS
1992 1993 1994 KAWASAKI JF650X2
1992 1993 1994 KAWASAKI JH750 Super Sport Xi
1992 1993 1994 KAWASAKI JH750SS
1992 1993 1994 KAWASAKI JH750XiR
1992 1993 1994 KAWASAKI JL650SC
1992 1993 1994 KAWASAKI JS440SX
1992 1993 1994 KAWASAKI JS550SX B Models with Piston Port Engines
1992 1993 1994 KAWASAKI JS650SX
1992 1993 1994 KAWASAKI JS750SX
1992 1993 1994 KAWASAKI JT750ST